Browsing by Author "Waterman, Kim M."
Now showing 1 - 3 of 3
Results Per Page
Sort Options
- Evaluation of Listeria monocytogenes and Staphylococcus aureus Survival and Growth during Cooling of Hams Cured with Natural-Source NitriteWu, Jian; Acuff, Jennifer C.; Waterman, Kim M.; Ponder, Monica A. (International Association of Food Protection, 2021-02-01)Growing consumer demand for clean-label “natural” products has encouraged more meat processors to cure meat products with natural sources of nitrate or nitrite such as celery juice powder. One challenge for these producers is to identify safe cooling rates in products cured with celery juice powder where extended cooling could allow growth of pathogens. The Food Safety and Inspection Service of the U.S. Department of Agriculture recently added guidelines for stabilization of meat products cured using naturally occurring nitrites based on control of Clostridium spp. However, a knowledge gap exists for safe cooling rates that prevent the growth of Listeria monocytogenes and Staphylococcus aureus, potential postlethality contaminants, in naturally cured ham. The study was conducted to investigate the temperature profiles of naturally cured hams of typical sizes during refrigerator cooling and to determine the behavior of S. aureus and L. monocytogenes on ham during these cooling periods. Whole hams (14 lb [6,300 g]), half hams (6 lb [2,700 g]), and quarter hams (3 lb [1,400 g]) were slowly cooked in a smokehouse until internal temperatures reached a minimum of 1408F (608C) and then were immediately transferred into a walk-in cooler (388F [3.38C]). Cooling times for hams of all sizes were within the requirements for cured products but not for uncured products. Worst-case scenarios of postprocessing surface contamination were simulated by inoculating small naturally cured ham samples with S. aureus or L. monocytogenes. These inoculated hams were then cooled under controlled conditions of 130 to 458F (54.4 to 7.28C) for 720 to 900 min. By the end of cooling, small decreases (0.5 to 0.6 log CFU/g) were found for each inoculum. These findings may help small ham processors evaluating production and quality control methods to determine whether recommended concentrations of natural curing agents used to prevent growth of clostridial pathogens may also prevent growth of other pathogens during meat cooling.
- Inoculation Preparation Affects Survival of Salmonella enterica on Whole Black Peppercorns and Cumin Seeds Stored at Low Water ActivityBowman, Lauren S.; Waterman, Kim M.; Williams, Robert C.; Ponder, Monica A. (Int Assoc Food Protection, 2015-07-01)Salmonellosis has been increasingly associated with contaminated spices. Identifying inoculation and stabilization methods for Salmonella on whole spices is important for development of validated inactivation processes. The objective of this study was to examine the effects of inoculation preparation on the recoverability of Salmonella enterica from dried whole peppercorns and cumin seeds. Whole black peppercorns and cumin seeds were inoculated with S. enterica using one dry transfer method and various wet inoculation methods: immersion of spice seeds in tryptic soy broth (TSB) plus Salmonella for 24 h (likely leading to inclusion of Salmonella in native microbiota biofilms formed around the seeds), application of cells grown in TSB, and/or application of cells scraped from tryptic soy agar (TSA). Postinoculation seeds were dried to a water activity of 0.3 within 24 h and held for 28 days. Seeds were sampled after drying (time 0) and periodically during the 28 days of storage. Salmonella cells were enumerated by serial dilution and plated onto xylose lysine Tergitol (XLT4) agar and TSA. Recovery of Salmonella was high after 28 days of storage but was dependent on inoculation method, with 4.05 to 6.22 and 3.75 to 8.38 log CFU/g recovered from peppercorns and cumin seeds, respectively, on XLT4 agar. The changes in surviving Salmonella (log CFU per gram) from initial inoculation levels after 28 days were significantly smaller for the biofilm inclusion method (z0.142pepper, z0.186cumin) than for the other inoculation methods (20.425pepper, 22.029cumin for cells grown on TSA; 20.641pepper, 20.718cumin for dry transfer; 21.998pepper for cells grown in TSB). In most cases, trends for reductions of total aerobic bacteria were similar to those of Salmonella. The inoculation method influenced the recoverability of Salmonella from whole peppercorns and cumin seeds after drying. The most stable inoculum strategies were dry transfer, 24-h incubation of Salmonella and spices in TSB (i.e., potential inclusion of Salmonella within native microbiota biofilms), and inoculation of Salmonella cells grown on TSA subsequent to drying. However, with the dry transfer method it was difficult to obtain the large amount of inoculum needed for inactivation studies.
- Sensory Lexicons and Formation Pathways of Off-Aromas in Dairy Ingredients: A ReviewSu, Xueqian; Tortorice, Monica; Ryo, Samuel; Li, Xiang; Waterman, Kim M.; Hagen, Andrea; Yin, Yun (MDPI, 2020-01-28)Consumers are becoming increasingly aware of the health benefits of dairy ingredients. However, products fortified with dairy proteins are experiencing considerable aroma challenges. Practices to improve the flavor quality of dairy proteins require a comprehensive understanding of the nature and origins of off-aroma. Unfortunately, existing information from the literature is fragmentary. This review presents sensory lexicons and chemical structures of off-aromas from major dairy ingredients, and it explores their possible precursors and formation mechanisms. It was found that similar chemical structures often contributed to similar off-aroma descriptors. Lipid degradation and Maillard reaction are two primary pathways that commonly cause aroma dissatisfaction. Traditional and novel flavor chemistry tools are usually adopted for off-aroma measurements in dairy ingredients. Strategies for improving aroma quality in dairy derived products include carefully selecting starting materials for formulations, and actively monitoring and optimizing processing and storage conditions.