Browsing by Author "Wilson, Christopher Allen"

Now showing 1 - 4 of 4
  • Thumbnail Image
    Carbon-efficient Wastewater Treatment Through Resource Recovery, Process Intensification, and Partial Denitrification Anammox
    Wang, Jiefu (Virginia Tech, 2024-05-28)
    Facing the pressure of population growth and global warming, this dissertation provided an array of innovative carbon-efficient wastewater treatment technologies for resource recovery, process intensification, and anammox featured next generation biological nutrient removal (BNR) technologies. These technologies aim to supplant traditional carbon-intensive treatment processes with more sustainable alternatives. To this end, the dissertation first comprehensively reviewed what resources can be recovered from wastewater, and how these valuable resources can contribute to the carbon neutrality in water resource reclamation facilities (WRRFs) and help achieve sustainable society development. Then, the effect of mixed liquor recycle (MLR) configurations on the process intensification through continuous-flow aerobic granulation was explored in plug flow reactors. The results demonstrated that MLR configuration could hinder the sludge granulation, but the hindrance could be alleviated to some extent by its location change. In order to eliminate the energy consuming MLR, endogenous denitrification was taken advantage through a synergistic integration with partial nitrification, partial denitrification anammox (PdNA), and enhanced biological phosphorus removal (EBPR). This idea was tested in a pilot setup treating real primary effluent under highly variable influent conditions and low temperatures. The results showcased substantial carbon savings while meeting the stringent effluent requirements. To take a deeper dive into the PdNA performance and the underlying mechanisms, two parallel pilot-scale moving bed biofilm reactor (MBBR) treatment trains fed with methanol and glycerol, respectively, were operated in a local WRRF. Their efficacies in achieving stringent nutrient removal targets and carbon savings were compared. The impacts of operational conditions on the mechanisms and performance were elucidated. In the culmination of this dissertation, a sidestream process intensification and resource recovery technique, namely thermal hydrolysis pretreatment (THP) enhanced anaerobic digestion (AD), was experimented to compare the efficiencies between thermophilic and mesophilic AD when integrated with THP. To sum up, this dissertation not only advanced our understanding of carbon-efficient wastewater treatment processes but also laid the groundwork for their practical implementation, contributing to the global effort towards sustainability.
  • Thumbnail Image
    The Effect of Steady-State Digestion Temperature on the Performance, Stability, and Biosolids Odor Production associated with Thermophilic Anaerobic Digestion
    Wilson, Christopher Allen (Virginia Tech, 2006-11-08)
    The performance and stability of a thermophilic anaerobic digestion system are inherently dependent on the engineered environment within each reactor. While the selection of operational parameters such as mixing, solids retention time, and digestion temperature are often selected on the basis of certain desirable outcomes such as the deactivation of human pathogens, these parameters have been shown to have a broad impact on the overall sludge digestion process. Since the current time-temperature requirements for biosolids pathogen reduction are most easily met at elevated digestion temperatures within the thermophilic range, it is certainly worth examining the effect of specific digestion temperatures on ancillary factors such as operational stability and the aesthetic quality of biosolids. A series of experiments were carried out in which wastewater sludge was digested at a range of temperatures (35°C, 49°C, 51°C, 53°C, 55°C, 57.5°C). Each reactor was operated for a period at steady state in order to make observations of microbial activity, digestion performance, and biosolids aesthetics as affected solely by digestion temperature. Results of this study show that poor operational stability arises in reactors operated at 57.5°C. Elevated concentrations of hydrogen and short-chain fatty acids in the 57.5°C digesters are evidence that the observed temperature-induced digester failures are related to the temperature sensitivity of hydrogenotrophic (CO₂-reducing) methanogens. Reactors operated at other temperatures performed equally well with respect to solids removal and operational stability. In addition, peak volatile organic sulfur compound (VOSC) production from biosolids treated at 51°C and above was greatly reduced in comparison with mesophilic anaerobic digestion and a lower temperature (49°C) thermophilic system. Since the biosolids methanogenic community appeared to be equally capable of degrading VOSC over the range of thermophilic temperatures, the conclusion is that the activity of VOSC producing organisms in digested and dewatered biosolids is greatly reduced when operating temperature in excess of 51°C are used. This study shows that small changes in an operationally defined parameter such as digestion temperature can have a large impact on the performance and stability of a digestion process. Single minded selection of digestion temperature in order to achieve effective pathogen reduction can result in poor digester performance and the production of an aesthetically unacceptable product. Careful selection, however, of an appropriate digestion temperature can not only ensure successful pathogen reduction in compliance with current regulations, but can also improve the performance, stability, and aesthetic quality of digestion systems employing thermophilic anaerobic digestion.
  • Thumbnail Image
    Mechanisms of Methanogenic Inhibition in Advanced Anaerobic Digestion
    Wilson, Christopher Allen (Virginia Tech, 2009-12-07)
    A series of lab-scaled digestion studies including conventional mesophilic anaerobic digestion(MAD), thermophilic anaerobic digestion (TAD) at a range of treatment temperatures, and mesophilic high solids digestion of thermally pretreated wastewater sludge (THD) were carried out. Enhanced digestion performance in terms of solids destruction and methane generation by THD relative to MAD was achieved, and was largely attributable to the solubilization and subsequent biodegradation of energy-rich substrates within blended primary and secondary sludge. TAD was observed to underperform MAD, especially at elevated temperatures as methanogenic inhibition resulted in the accumulation of headspace hydrogen, thus resulting in poor removal of volatile fatty acids. The thermodynamics of fatty acid metabolism was favorable at each digestion temperature, thus it was concluded that microbial inhibition was the controlling factor in poor thermophilic performance. Inhibition by free unionized ammonia (NH₃) was characterized for THD and MAD biomass. Acetic acid degradation was equally affected over a range of NH₃ concentrations; however, methane generation by THD was less sensitive to ammonia inhibition, thus suggesting that methanogenesis by THD was less dependent on the NH₃-sensitive process of aceticlastic methanogenesis. Total ammonia nitrogen (TAN) and bicarbonate alkalinity were stoichiometrically produced from proteinaceous material during thermal hydrolytic pretreatment and subsequent high solids anaerobic digestion. Combined effects of TAN and high pH resulted in NH₃-inhibition during THD. Kinetic evaluations suggested that a growth rate reduction of approximately 65% was associated with in-situ NH₃ concentrations of the THD reactor. NH₃-inhibition was apparently responsible for a shift in dominant methanogenic community of the aceticlastic Methanosarcina barkeri in MAD to the hydrogenotrophic Methanoculleus bourgensis in THD. A similar shift in methanogenic community was observed between low temperature thermophilic digestion at 47°C, where the dominant order was Methanosarcinales, to high temperature thermophilic digestion at 59°C where the dominant order was Methanobacteriales. These findings support a process-driven pathway shift from aceticlastic to non-aceticlastic methanogenesis between 180 and 290 mg/L NH₃-N. Such a threshold is supported by previous literature related to ammonia tolerance of pure cultures of methanogens and has significant implications for the kinetic design of advanced anaerobic digestion processes.
  • Thumbnail Image
    Removal of Total Organic Carbon and Emerging Contaminants in an Advanced Water Treatment process using Ozone-BAC-GAC
    Vaidya, Ramola Vinay (Virginia Tech, 2020-06-17)
    Indirect potable reuse has been practiced with the potential to enhance sustainability of water resources if planned accordingly. Depending on the pretreatment implemented for potable reuse, emerging contaminants; such as pharmaceuticals, personal care products, industrial solvents, bacterial/viral pathogens, and disinfection byproducts, might be present in source water and difficult to remove via various water treatment technologies. Low molecular weight organic compounds are especially challenging to remove and may require treatment optimization. The overarching purpose of this study was to demonstrate the feasibility of a carbon-based advanced treatment train; including ozonation, biological activated carbon (BAC) filtration and granular activated carbon (GAC) adsorption to achieve water quality suitable for potable reuse and assess the impact of a range of operating conditions for emerging contaminant removal at pilot-scale. The results from this study showed that carbon-based treatment train is equally effective as more commonly used, and more costly, membrane-based treatment trains in terms of pathogen and disinfection byproduct removal. A multiple-barrier approach was implemented, with each treatment stage capable of removing total organic carbon (TOC). GAC was responsible for removal of most of the TOC and emerging contaminants and this removal depended on the number of bed volumes of water processed by GAC. Empty bed contact time was another factor that dictated the extent of TOC removal in the BAC and GAC units as the carbon media was exhausted. Among the emerging contaminants detected, sucralose, iohexol and acesulfame-k were present in the highest concentrations in the influent and were detected consistently in the GAC effluent, thus making them good indicators of treatment performance. Apart from organics removal, BAC played an important role in removal of nutrients, such as ammonia via nitrification. N-Nitrosodimethlyamine (NDMA) was formed in the treatment process by ozone, but was shown to be effectively removed by BAC. EBCT, temperature, ozone dose and presence of pre-oxidants, such as monochloramine, played an important role in determining the amount of NDMA removed. These factors can be further optimized to improve NDMA removal. Sodium bisulfite was used for dechlorinating monochloramine residual post ozone. Nitrification in the BAC was shown to be inhibited by excess of sodium bisulfite dose. Thus monochloramine residual needs to be dechlorinated with sodium bisulfite to help with NDMA degradation but at the same time the sodium bisulfite dose needs to be monitored to allow complete nitrification in the BAC. 1,4-dioxane, another contaminant of emerging concern, was monitored in the treatment process. Biodegradation of 1,4-dioxane was enhanced via addition of tetrahydrofuran as a growth substrate. Biodegradation of 1,4-dioxane can help reduce energy and capital costs associated with advanced oxidation processes that are currently used for 1,4-dioxane removal. Further, relying on biodegradation for the removal of 1,4-dioxane can help avoid the formation of disinfection byproducts associated with advanced oxidation processes such as ozone with peroxide or ultraviolet disinfection with peroxide. The results from this project can be useful for designing potable reuse treatment trains and provide a baseline for removal of organic carbon and emerging contaminants. The conventionally used reverse osmosis and ultrafiltration approach is useful for organics removal in areas where the rationale behind potable reuse is water scarcity. Operational difficulties encountered during this study can prove to be important as this treatment process is scaled up to treat a total of 120 MGD of water for managed aquifer recharge. Overall the lessons learnt from this study can give a better understanding of a carbon-based treatment and further the advancement of reuse projects that have drivers other than water scarcity.